Honda Odyssey Service Manual: Sliding Door Center Rail Replacement

NOTE:

  • Put on gloves to protect your hands.

  • Take care not to scratch the body.

  • Use seat covers to avoid damaging any surfaces.

  1. Remove these items:

    • Sliding door

    • Rear side trim panel

    • Second row seat belt retractor

    • Right side: Rear HVAC unit

  1. Manual sliding door: Remove the center roller (A) from the center rail.

  2. A
  1. Remove the center rail cover (A).

    1. Remove the screw (B) and the bolts (C).

    1. Slide the center rail cover rearward. The clips (D) will stay in the body.

    1. Remove the clips from the body by turning them 45°.

  2. Fastener LocationsC ? : Bolt, 2ADDB ? : Screw, 1B6 x 1.0 mm9.4 N·m (0.96 kgf·m, 6.9 lbf·ft)D ? : Clip, 6DDDDDCC
  3. Install the clips on the center rail cover.

  4. Power sliding door: Remove the center roller.


  1. Remove the nuts from inside of the vehicle.

  2. Fastener Locations? : Nut, 56 x 1.0 mm9.4 N·m (0.96 kgf·m, 6.9 lbf·ft)
  1. Remove the center rail (A).

  2. A

  1. If necessary, remove the center rail grommet (A) and center rail seals (B).

  2. ABB
  1. Power sliding door: If necessary, remove the center rail cable guide (A).

  2. A
  1. Install the center rail in the reverse order of removal, and note these items:

    • If the clips for the center rail cover are damaged or stress-whitened, replace them with new ones.

    • Take care to tighten the front nut of the center rail first, before tightening any other nuts.

    • Clean the groove area of the center rail (A). Apply multipurpose grease to the corner area of the sliding door, as shown.

  2. ?A
    Special Tools Required

    Sliding Door Guide Pin Replacement

    See More:

    Honda Odyssey Service Manual > Brake Control and Vehicle Dynamics: BSI OFF Switch Test/Removal/Installation
    Push out the BSI OFF switch (A) from the back of the dashboard, and disconnect the BSI OFF switch 6P connector (B). AB On the switch side, check for continuity between the BSI OFF switch 6P connector terminal in each switch position according to the table. 6 5 4 3 2 1 BSI OFF SWITCH 6P CONNECTORTer ...

    Honda Odyssey Owners Manual

    Honda Odyssey Service Manual

    © 2018-2025 Copyright www.hodyssey.net
    0.0136